frost free hydrant problems

I would buy one because even though they are frost free the handlesnozzle can freeze up during cold weather usually freezing rain is a problem as well. Last summer we had a frost free hydrant installed outside the barnThis year weve had an unusually cold winter and now were not able to lift the handleThinking it was frozen we slowly warmed up the above ground section of pipe about 3 and the handle using a weed burner.

800sb Series Deluxe Frost Proof Yard Hydrant Certified Lead Free Simmons Manufacturing Company

Ive got a Merrill yard hydrant that has slowly deteriorated to a mere drip.

. A Common Cause of Frost-Free Yard Hydrant Failure - External Corrosion. One of the main reasons is external corrosion of the riser pipe. So the upright part of the pump that is sticking out of the ground can drain through a small weep hole to prevent freezing.

But we are still unable to raise the handle to get water. For the longest time I didnt know about the set screw and dug up one hydrant to replace it. Every time you use the hydrant a half cup of water drains out of the pipe.

I have a Campbell yard hydrant that has been installed for about 8 years. To determine if the water is not draining out the stand pipe turn the hydrant on and let the water flow. Then push down the handle to close the hydrant with a cup of water covering the nozzle.

Frost free hydrant leaking. The water drains out of the faucet and standpipe and into. With the heat tape you pay an annuity to the PoCo.

I removed the hose today that was full of ice as the hydrant wo noticing any cracks and covered it. Frost free hydrants require two things. I went to replace teh plunger and other parts with a rebuild kit when the hydrant stopped workingand when i pulled out the main rod I found that it has sheared off right.

I noticed the ground around my hydrant stays wet all the time now. It is a potentially major problem. I live in an area of red clay that would take months to drain away.

The hydrants are connected to the water distribution system and possess a drain-back feature that allows the water standing in the column to drain below the frost line and discharge through a. These hydrants are designed for use where freezing is a problem to allow year-round water service on private water supplies without the danger of damage to the pipes or hydrants. Today I dug down looking for a leak and found what I believe is the drain hole for the hydrant has water coming from it in a steady stream.

With the frost free you pay a lump sum upfront. Its the digging part that I am most bummed about. My concern is will the ice in the hydrant expand more with lower temps coming that could crack it.

Ive had problems with leaky yard hydrants too. The above ground portion is filled with water and will freeze and potentially burst in cold weather. I have a frost free hydrant in my yard halfway between my home and my well.

At some point in the future probably years your total annuity payments will exceed the lump sum. The bottom of the standpipe reaches below the frost linethe depth to which the ground freezes in winter. Trouble shooting guide for yard hydrants used on farms and other locations to provide water for livestock maintenance and other operations.

Instructions Adjustment Worn. The hydrant does not leak from the. The drain hole must open when the lever snaps shut.

Only show this user. Typically a yard hydrant installation is comprised of a buried horizontal pipe that leads to a long vertical pipe called a standpipe that automatically drains the water out each time the hydrant is shut off. If the water in the cup siphons back through the hydrant the plunger is in the correct position.

This is because a dripping frost free hydrant is no longer frost free. I missed removing a water hose and covering a frost free hydrant before we got into instant teens in North TX. Its given my trouble now and then but this is my worst problem yet.

You can rent a blow torch hand held propane torch if you dont want to buy one. When setting a new frost free hydrant you should place about a foot 12 of medium sized gravel under the pump foot valve. The photo below was sent to us by a recent customer in New York.

6 Aug 16 2021. Yard Hydrant Troubleshooting. Frost Free Hydrant Questions.

So the problem is obviously a restriction in the hydrant. A dripping frost free or freeze proof yard hydrant is more than an unsightly water waster. I still have this problem at my older barn I will have to dig it out and place more stone under it.

Frost-free yard hydrants also know as ground hydrants hose bibs or yard faucets can fail for many reasons. For me it would be 15 cents per kWh used by the tape. I live in Northern Lower Michigan and have 3 frost free hydrants.

I was sure that my problem was a crushed water line under our driveway but when I dug it up and intentionally cut the pipe I see that there is no problem with pressure or volume. When you dig it up and are ready to back fill get a piece of 12 pvc pipe about 2 long and put that in the ground as a liner and put a waterproof top on it and fill it with insulation and no more digging it up. I have seen those kits.

Then a contractor friend showed me. A self ingniting torch will be handy right about then but a hair dryer and an extension cord will work as well. The one at the fence line which feeds water into my livestock tank has water leaking down below.

But the water needs a place to go.

How To Adjust And Repair A Boshart Yard Hydrant